Kim, Jaehoon Taylor, Douglas DeYoung, James McClain, James B. DeSimone, Joseph M. Carbonell, Ruben G. 2024-01-20T21:35:25Z 2024-01-20T21:35:25Z 2021-09-03 2009-03-10 0897-4756 https://pubs.kist.re.kr/handle/201004/132654 Copper (Cu) particles and films were produced by forming Cu(II) compound (Cu(hfac)(2)center dot H2O) films on substrates using a displacement from two immiscible supercritical phases (DISP) technique followed by reducing the copper(II) compound films in hydrogen at 200 degrees C. Various surfaces including native oxide of silicon (SiOx), titanium nitride (TiN), tungsten (W), and low-k dielectric materials such as Coral, JSR5109, and Silox were used as substrates. The nucleation and growth behavior of the Cu DISP process was evaluated over a range of reduction times (from 5 to 60 min) and copper(II) compound concentrations (0.5-3 wt %). At short reduction periods (5-15 min) or low Cu(II) compound concentrations (similar to 0.5 wt %), Cu particles ranging from 60 to 95 nm in diameter were produced. In contrast, at long reduction periods (45-60 min) and high concentrations (similar to 3 wt %), continuous Cu films with 220-450 nm in thickness were deposited on the substrates. A morphology transition from particle to film was observed at medium reduction period (similar to 30 min) or medium concentration range (similar to 1 wt %). High affinity of TiN to Cu nucleation and film formation leads to more dense and smooth films than Cu films deposited under similar conditions on SiOx. However, nucleation of Cu DISP is not very sensitive to the surface conditions of the substrates compared with Cu CVD (chemical vapor deposition). Chemical composition analysis of the Cu film on TiN and SiOx by X-ray photoelectron spectroscopy (XPS) and secondary ion mass spectrometry (SIMS) revealed that highly pure Cu films were obtained from Cu DISP. English AMER CHEMICAL SOC CHEMICAL-VAPOR-DEPOSITION ULTRALARGE SCALE INTEGRATION OXIDE FUEL-CELL CU NANOPARTICLES NANOCRYSTALLINE COPPER OPTICAL-PROPERTIES CONFORMAL COPPER DIRECT OXIDATION INITIAL GROWTH THIN-FILMS Deposition of Copper Particles and Films by the Displacement of Two Immiscible Supercritical Phases and Subsequent Reaction Article 10.1021/cm802659j 1 CHEMISTRY OF MATERIALS, v.21, no.5, pp.913 - 924 CHEMISTRY OF MATERIALS 21 5 913 924 scie scopus 000263891700019 2-s2.0-65249083896 Chemistry, Physical Materials Science, Multidisciplinary Chemistry Materials Science Article CHEMICAL-VAPOR-DEPOSITION ULTRALARGE SCALE INTEGRATION OXIDE FUEL-CELL CU NANOPARTICLES NANOCRYSTALLINE COPPER OPTICAL-PROPERTIES CONFORMAL COPPER DIRECT OXIDATION INITIAL GROWTH THIN-FILMS Copper Particles Copper film Supercritical Phases deposition